1996 Ford explorer XLT

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

VEHICLE SPEED CONTROL

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEA…

Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

SUSPENSION

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE.

Remedy: DEALERS WILL REPLACE BOTH THE LEFT AND RIGHT FRONT SWAY BAR LINKS.

TIRES:TREAD/BELT

TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.

Remedy: THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.

TIRES:TREAD/BELT

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURIN…

Remedy: THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.

STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT

VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE LIFTGATE ASSIST GAS CYLINDER BRACKET ON THE RIGHT HAND BODYSIDE OUTER PANEL WAS INCORRECTLY WELDED.

Remedy: DEALERS WILL REINFORCE THE BRACKET ATTACHMENT WITH TWO POP RIVETS.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."

Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.

EQUIPMENT:OTHER:LABELS

THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.

VEHICLE SPEED CONTROL

VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TE…

Remedy: DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.

SEAT BELTS

WHILE STATIONARY AND PREPARING TO SAFELY OPERATE THE VEHICLE, THE DRIVER'S SIDE SEAT BELT RECEPTACLE DOES NOT RETAIN THE SEAT BELT. IT MAY HOLD FOR A BRIEF MOMENT, BUT THEN RELEASES THE BELT RENDERING THE SEAT BELT SYSTEM INEFFECTIVE AND UNSAFE.

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,SEATS

WHILE DRIVING IN "D" IN FIRST TO SECOND IT HAS HAD A PROBLEM SHIFTING BETWEEN THE 1ST AND 2ND GEARS WHEN ACCELERATING AND WILL REV HIGH RPMS AND SOMETIMES DO ABSOLUTLEY NOTHING WHEN DRYING TO MOVE FORWARD UNLESS I DE ACCELERATE AND THEN TRY TO ACCELERATE AGINE THEN FINALLY IT WILL CATCH AND GO IN TO 2ND AND PROCEED TO 3RD AND THEN 4TH AND THEN 5TH ,4TH …

WHEELS

THE RIMS ON THIS 1996 FORD EXPLORER-EDDIE BAUER EDITION ARE SHOWING FRACTURES THROUGHOUT THE FACE. THIS HAS WEAKENED THE STABILITY OF THE RIMS.

ELECTRICAL SYSTEM

ALL FOUR WINDOWS INTERMITTENTLY STOP WORKING. CANNOT GO UP OR DOWN. DOESNT HAVE A PREFERENCE AS TO WHEN, HAPPENS WHEN THE CAR IS OFF OR ON.

SEAT BELTS

TL* THE CONTACT OWNS A 1996 FORD EXPLORER. THE CONTACT STATED THAT THE PASSENGER SIDE SEAT BELT WAS JAMMED AND WOULD NOT UNLATCH. AS A RESULT, THE CONTACT HAD TO CUT THE SEAT BELT. JIM HUDSON FORD (1201 W MAIN ST, LEXINGTON, SC) WAS CONTACTED, BUT THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 672,000.

ENGINE,FUEL/PROPULSION SYSTEM

I PURCHASED THIS EXPLORER THE FIRST YEAR THAT THE V-8 WAS AVAILABLE. THE EXHAUST MANIFOLD FRACTURED 4 TIMES DURING THE 12 YEARS THAT I HAD THE VEHICLE. THE PART COST OVER $300 AND WAS ON "NATIONAL BACKORDER" FOR OVER A YEAR, SO I HAD MY NEPHEW (CERTIFIED WELDER) WELD THE PIECE TOGETHER AND REINSTALLED BY AN AUTO MECHANIC. MY NEPHEW STATED THAT WHEN YOU HA…

VEHICLE SPEED CONTROL

SAFETY RECALL 09S09 - SCDS (SPEED CONTROL DEACTIVATION SWITCH) ON FORD MODELS MADE AFTER 95 WITH A TEXAS MADE DEACTIVATION SWITCH THAT WAS MADE POORLY. I PURCHASED A 1996 FORD EXPLORER EDDIE BAUER EDITION 4X4 TRUCK IN DECEMBER OF 2016, FROM A PRIVATE PARTY IN NEVADA.THE VEHICLE WAS PURCHASED MAINLY SO I COULD DELIVER AS PART OF MY JOB DESCRIPTION AND NEEDE…

AIR BAGS,WHEELS,UNKNOWN OR OTHER

I WAS DRIVING MY FORD EXPLORER AND MY TIRE ON THE DRIVER FRONTSIDE WENT OUT AND MY STEERING WHEEL LOCKED UP ON ME AND THEN MY VEHICLE HIT THE CURVE AND FLIPPED OVER 15 OR 16 TIMES BEFORE IT STOPPED I WAS FEELING ALL OVER THE ROAD I HAD MY SET BELT ON BUT MY AIR BAGS NEVER CAME OUT AND I WAS ONLY GOING 25 OR 30 AND I WAS ON A CITY STREET TURNING INTO THE NEXT…