1997 Ford crown victoria Base

STEERING

Dorman Products, Inc. (Dorman) is recalling certain model Dorman Steering Shafts, part number 425-359, Solutions Steering Shafts, part number 7-0359, and OE Solutions Steering Shafts, part number 425-359, manufactured April 17, 2014, to September 28, 2015. These aftermarket replacement steering shafts are sold for use in 1995-2002 Ford Crown Victoria, Mercury Grand Marquis, and Lincoln Town Car v…

Remedy: Dorman will notify owners, and dealers will replace the steering shaft, free of charge. The recall began on October 28, 2015. Owners may contact Dorman customer service at 1-800-523-2492, option 5.

VEHICLE SPEED CONTROL:CRUISE CONTROL

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

ON CERTAIN PASSENGER VEHICLES BUILT WITH ELECTRONIC TRACTION CONTROL, THE REAR BRAKE LINE MAY CHAFE DUE TO CONTACT BETWEEN IT AND A FLOOR PAN STIFFENING RIB, AND A BRAKE FLUID LEAK MAY OCCUR.

Remedy: DEALERS WILL INSPECT THE SUBJECT VEHICLES FOR CONTACT BETWEEN THE BRAKE TUBE AND FLOOR PAN STIFFENING RIB. IF CONTACT IS EVIDENT, BUT NO ABRASION OR LEAKS EXIST, THE BRAKE TUBE WILL BE REPOSITIONED TO PRECLUDE FURTHER CONTACT AND POTENTIAL ABRASION. IF INDICATION OF ABRASION OR A LEAK IS EVIDENT, D

SEAT BELTS:FRONT:ANCHORAGE

VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET FRONT PASSENGER SIDE SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, B…

Remedy: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.

VEHICLE SPEED CONTROL

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES.

Remedy: FORD HAS ADVISED US THAT SHIELD KITS HAVE BEEN AVAILABLE SINCE LATE OCTOBER AND WILL BE INSTALLED ON POLICE INTERCEPTOR VEHICLES AT NO COST. THE OPTIONAL TRANK PACKAGE WILL BE AVAILABLE BY THE END OF 2002. FORD HAS ESTABLISHED A NEW WEB SITE AT WWW.CVPI.COM TO ANSWER ADDITIONAL QUESTIONS ABOUT THE

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

ON CERTAIN NATURAL GAS VEHICLES, IF A FLAME FROM A VEHICLE INTERIOR FIRE BECOMES LOCALLY DIRECTED AT THE NATURAL GAS FUEL TANK LOCATED IMMEDIATELY BEHIND THE REAR SEAT, THE FLAME COULD DAMAGE THE FIBERGLASS WRAP ON THE TANK WEAKENING THE TANK.

Remedy: DEALERS WILL INSTALL AN INSULATOR BEHIND THE CURRENT SEAT BACK. OWNER NOTIFICATION BEGAN ON JANUARY 7, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

SEAT BELTS:FRONT:ANCHORAGE

VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET DRIVER'S SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW …

Remedy: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. FORD IS INITIATING AN OWNER NOTIFICATION PROGRAM FOR OWNERS OF CERTAIN 1995-1997 CROWN VICTORIA MODEL VEHICLES WITH POLICE, TAXI, AND COMMERCIAL FLEET PACKAGES AND TOWN CAR VEHICLES WITH THE LIVERY PACKAGE. THESE VEHICLES MAY HAVE INSUFFICIENT CLEARANCE BETWE…

Remedy: DEALERS WILL INSPECT THE BRAKE LINES FOR WEAR, INSTALL TWO NEW TUBE BUNDLE CLIPS, AND CHECK THE BRAKE LINES FOR PROPER CLEARANCES. IF THE BRAKE LINES ARE WORN, THE DAMAGED SECTION OF THE BRAKE LINE WILL BE REPLACED.

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING…

Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).

LATCHES/LOCKS/LINKAGES:HOOD:LATCH

VEHICLE DESCRIPTION: POLICE AND TAXI VEHICLES. THE HOOD LATCH STRIKER CAN WEAR OR BECOME DETACHED FROM THE HOOD.

Remedy: DEALERS WILL INSTALL AN IMPROVED HOOD LATCH STRIKER (VEHICLES WITH 1992 MODEL HOODS) OR REVISED STRIKER PLATE ATTACHING FASTENERS (VEHICLES WITH 1993-1997 MODEL HOODS).

SUSPENSION

The contact owns a 1997 Ford Crown Victoria. The contact stated that while driving at an undisclosed speed, the steering wheel jerked, and the vehicle became difficult to maneuver. Additionally, the contact stated that the seat belt warning light was illuminated, and other unknown warning lights were illuminated. The vehicle was towed to an independent mecha…

VISIBILITY/WIPER

WIPER LIVE 4 IN SPOT EYE LEVEL CANT SEE IN RAIN REPLACE ARM AND WIPER BLADE STILL HAVE SPOT.

ENGINE

THE CAR HAS A FIBER GLASS INTAKE AND MY CAR HAS ABOUT 75,000 MILES..A FIBERGLASS INTAKE IS A DEFECTED PRODUCT FOR THIS PART OF A ENGINE,BECAUSE OF THE HEAT.I BOUGHT THIS CAR NEW AND EVEN PAID FOR THE EXTENDED WARRENTY..FORD MOTOR CO. SHOULD REPLACE THIS DEFECT PART,,FOR FREE..I HAD TO PARK MY CAR OVER 3 YEARS AGO..

SERVICE BRAKES

HYDRAULIC LINE TO REAR BRAKE FAILED (RUPTURED) CAUSING IMMEDIATE RELEASE OF BRAKE FLUID UNDERNEATH DRIVER FRONT FLOOR PAN AT LOCATION OF INTEREST MENTIONED IN RECALL/"SAFETY IMPROVEMENT PROGRAM". OWNER WAS NOT CONTACTED REGARDING NOTICE WHICH INCLUDES INSPECTION OF BRAKE LINES, REPLACEMENT OF CLIPS (TO AVOID WEAR) AND POSSIBLE REPLACEMENT OF BRAKE LINE AND …

ELECTRICAL SYSTEM,INTERIOR LIGHTING

TL* THE CONTACT OWNS A 1997 FORD CROWN VICTORIA. THE CONTACT STATED THAT WHEN THE HEADLIGHTS WERE ACTIVATED, THE INSTRUMENT PANEL, CLOCK, AND RADIO LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 151,000.

STEERING

DRIVING EAST ON ALLEN STREET IN SPRINGFIELD MASSACHUSETTS STEERING CONTROL LOCKED UP RESULTING IN A CRASH WITH A GAS STATION PUMP POLICE CRASH REPORT ID 15-3725-AC CAR WAS TOTALLED OUT WHEN IT CAUGHT FIRE NO NOISE WAS HEARD SECONDS BEFORE CRASH. I HAVE NOTICED THAT THERE WAS A RECALL ON THE REPLACEMENT PARTS BUT WONDER IF THE OEM PARTS COULD FAIL RESULTING…

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 1997 FORD CROWN VICTORIA. WHILE ATTEMPTING TO ACCELERATE, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TIRES, TIE RODS, BALL JOINTS, BRAKES, AND BATTERY WERE REPLACED. HOWEVER, THE FAILURE KEPT RECURRING. ON ANOTHER OCCASION, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE VE…

ELECTRICAL SYSTEM,EXTERIOR LIGHTING

1997 FORD CROWN VICTORIA. VEHICLE HAS HAD REPAIRS DONE IN THE PAST AND STILL RECEIVES SAME PROBLEMS DUE TO RECALL. *TA THE CONSUMER STATED THE VEHICLE INTERMITTENTLY SHUT DOWN. A DIAGNOSE REVEALED A PROBLEM WITH THE LIGHTING CONTROL MODULE. ONCE IT WAS REPLACED, THE CONSUMER DID NOT EXPERIENCE ANY MORE PROBLEMS UNTIL THE SUMMER 2014 WHEN THE SAME PROBLEM R…