1994 Volvo 850 GLTS
YV1LS5519R2169757
Vehicle history report for the 1994 Volvo 850 GLTS (VIN YV1LS5519R2169757). White, sedan/saloon, 2.4L 5-cyl, gasoline. 131,086 mi reported. Registered in Wa. 3 open safety recalls. Unlock full title, salvage, lien & accident history.
At a glance
Vehicle identity & specifications
Full vehicle history report
What a full report checks for VIN YV1LS5519R2169757
A full report searches national title databases (NMVTIS) and licensed history providers for this VIN and shows whatever records are on file — not every vehicle has every record type. The decode, safety recalls and owner complaints above are always free.
Safety recalls 3
FUEL SYSTEM, GASOLINE:STORAGE
ON CERTAIN PASSENGER VEHICLES, AFTER PROLONGED EXPOSURE TO HEAT, THE FUEL TANK MAY SEEP OR LEAK FUEL AT THE POINTS WHERE THE HEAT SHIELD IS ATTACHED.
Remedy: VOLVO WILL INSPECT THE FUEL TANK AND REPLACE IT IF ANY EVIDENCE OF FUEL SEEPAGE OR LEAKAGE IS FOUND. ALL VEHICLES WILL RECEIVE NEW REINFORCEMENT BUSHINGS AT THE HEAT SHIELD ATTACHMENT POINTS TO PREVENT FUTURE LEAKS. THIS RECALL WILL BE CONDUCTED AS A SAFETY RECALL IN THE HOT WEATHER STATES OF
NHTSA Campaign #04V368000 · 30/07/2004VEHICLE SPEED CONTROL
UNDER VERY COLD WEATHER CONDITIONS, ICE CRYSTALS CAN FORM AT THE THROTTLE IN THE ENGINE INTAKE SYSTEM, AND PREVENT THE THROTTLE FROM RETURNING TO IDLE.
Remedy: DEALERS WILL REPLACE THE THROTTLE BODY, THROTTLE CABLE, CHARGE AIR COOLER PIPING AND CRANKCASE VENTILATION HOSES.
NHTSA Campaign #94V173000 · 13/09/1994ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ENGINE BLOCK HEATERS INSTALLED AS ACCESSORIES. THE BLOCK HEATER CONTACT SURFACE DOES NOT MATCH CORRECTLY WITH THE ENGINE BLOCK AS INTENDED. THE BLOCK HEATER COULD COME LOOSE FROM THE ENGINE BLOCK, AND IF BEING USED, COULD POSSIBLY OVERHEAT CAUSING DAMAGE IF IT COMES IN CONTACT WITH OTHER ENGINE COMPARTMENT COMPONENTS.
Remedy: DEALERS WILL INSPECT THE BLOCK HEATER AND SECURE THE BOLTS USED TO INSTALL THE HEATER. IN SOME CASES, THE SURFACE TOLERANCES MAY BE SO INAPPROPRIATE THAT THE HEATER WOULD NEED TO BE REPLACED WITH A HEATER OF A MODIFIED DESIGN.
NHTSA Campaign #96E025000 · 20/08/1996We'll email you the moment a new safety recall is issued — no spam, unsubscribe any time.
Common problems & what to inspect
Based on 107 owner complaints filed with NHTSA for the 1994 Volvo 850, here are the most-reported problem areas — and exactly what to check before you buy.
🚑 3 reported injuries
🔍 Sniff for fuel odor, check for leaks, hard starts or stalling, and confirm the fuel gauge reads correctly.
🔍 Have a trusted mechanic inspect this system as part of a pre-purchase inspection.
🔍 Check for fuel or battery warnings, hard starts and stalling. On a hybrid/EV, confirm charging and range behave normally.
🔍 Confirm the airbag light turns on then off at startup — if it stays lit there's a fault (costly, and a safety risk). Check for signs of prior deployment.
🔍 Check coolant level and color, look for leaks, and confirm the engine reaches normal temperature without overheating.
🔍 Have a trusted mechanic inspect this system as part of a pre-purchase inspection.
Pre-purchase checklist
- Match the VIN on the dash, door jamb and title — they must be identical.
- Cold-start the engine; listen for knocks and check for blue or white exhaust smoke.
- Test-drive through all gears at low and highway speed — no slipping, shudder or pulling.
- Confirm every warning light clears at startup (none should stay on).
- Check fluids — oil, coolant, transmission — for level, color and leaks.
- Look underneath for rust, fresh undercoating or signs of collision repair.
- Always get an independent pre-purchase inspection from a trusted mechanic.
Owner complaints 107
Complaints filed with NHTSA by owners of the 1994 Volvo 850.
FUEL/PROPULSION SYSTEM
I HAVE A 1994 VOLVO 850. I HAVE A LEAK WHERE THE HEAT SHIELD IS ATTACHED TO THE GAS TANK. VOLVO IS WELL AWARE OF THIS PROBLEM BUT MY VIN DOES NOT SHOW THE RECALL. THE LEAK OF GAS IS 100% FROM THE RECALLED SPOT HEATSHIELD SIDE OF THE GAS TANK. THIS IS A SAFETY ISSUE BECAUSE IT COULD BLOW BACK ON THE EXHAUST AND CAUSE A FIRE.
NHTSA ODI #11144772FUEL/PROPULSION SYSTEM
WE SMELL GAS. WHEN STOP NOTICE FUEL LEAKING FROM FUEL ENTRY PIPE. WHEN GOT CLOSER LOOK IT WAS LEAKING FROM FUEL ENTRY PIPE THAT CONNECTED TO FUEL TANK. *TR
NHTSA ODI #10668540AIR BAGS
THE CONSOLE AND STEERING WHEEL WERE WET FROM RAIN. THE SRS DASH WARNING LIGHT CAME ON. ABOUT 5 MILES AFTER THAT, THE DRIVER'S SIDE AIR BAG DEPLOYED. THE BAG WAS THE ORIGINAL BAG. THE SRS LIGHT HAD GONE ON ONCE 20 MONTHS BEFORE WHEN THE CONSOLE GOT WET. THE DEALERSHIP RAN A TEST FOR ABOUT $115 EACH ON BOTH OCCASIONS AND SAID THE CAUSE OF THE SRS LIGHT…
1 injured · NHTSA ODI #10471432FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1994 VOLVO 850 TURBO. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, FUEL LEAKED FROM UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THAT THE REMEDY FOR THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 04V368000 (FUEL SYS…
NHTSA ODI #10457791ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 1994 VOLVO 850. THE CONTACT STATED THAT THE RADIATOR FOR THE HEATING CORE WAS LEAKING AND EMITTING CHEMICAL FUMES INTO THE VEHICLE. AS A RESULT, THE CONTACT SUFFERED A SEVERE RESPIRATORY PROBLEM. THE CONTACT WAS TAKEN TO THE HOSPITAL ON VARIOUS OCCASIONS FOR TREATMENT. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED…
1 injured · NHTSA ODI #10448829FUEL SYSTEM, GASOLINE
I HAVE HAD THE SMELL OF GAS AND EVIDENCE OF LEAKS AT THE GAS TANK FOR ABOUT TWO YEARS PLUS. I CALLED VOLVO TWO YEARS AGO ABOUT THE RECALL (NHTSA # EA03008 FROM JULY/2004). I WAS TOLD THAT MY CAR VIN DOES NOT MATCH THE RECALL. I JUST HAD THE TANK PULLED BY MY MECHANIC AND IT IS A PLASTIC TANK WHICH IS LEAKING FROM THE 3 BOLTS WHICH ATTACH IT TO THE HEAT SHIE…
NHTSA ODI #10415678FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1994 VOLVO 850. THE CONTACT STATED HE NOTICED GASOLINE LEAKING FROM THE LEFT SIDE OF THE FUEL TANK. HE ADDED GASOLINE TO THE VEHICLE AND NOTICED THE LEAK CONTINUED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE THEY DISCOVERED SEVERAL CRACKS ON THE HEAT SHIELD ATTACHED TO THE FUEL TANK. A NEW FUEL TANK WAS ORDERED FOR THE CONT…
NHTSA ODI #10340562LATCHES/LOCKS/LINKAGES
BECAUSE OF FAILURE OF INTERNAL LATCHING MECHANISMS, THE DOORS OF THE 1994 VOLVO 850 (AND POSSIBLY OTHER MODELS) AFTER BEING CLOSED CAN SUDDENLY AND WITHOUT WARNING BE RENDERED PERMANENTLY CLOSED AND UNABLE TO BE OPENED FROM EITHER INSIDE OR OUTSIDE THE VEHICLE. USE OF THE VEHICLE KEY, DOOR LOCKS OR DOOR HANDLES ARE INEFFECTIVE AT ALLOWING AN AFFECTED DOOR T…
NHTSA ODI #10335363+ 99 more complaints on record.
