1998 Ford Ranger XLT

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

VEHICLE SPEED CONTROL

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

TIRES:TREAD/BELT

TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.

Remedy: THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.

TIRES:TREAD/BELT

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURIN…

Remedy: THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.

EQUIPMENT:OTHER:LABELS

VEHICLE DESCRIPTION: LIGHT DUTY FOUR-WHEEL DRIVE PICKUP TRUCKS EQUIPPED WITH OFF-ROAD OPTION. THE TIRE AND RIM IDENTIFICATION INFORMATION IS INCORRECT ON THESE VEHICLES. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Remedy: OWNERS WILL BE SENT A SAFETY CERTIFICAITON LABEL PARTIAL OVERLAY WHICH WILL CONTAIN THE CORRECT RIM SIZE, AND INSTRUCTIONS FOR AFFIXING THIS LABEL TO THE VEHICLE. IF AN OWNER SO DESIRES, THEIR FORD DEALER CAN INSTALL THE LABEL FOR THEM.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4.0L ENGINES. THE FLEXIBLE SECTION OF THE CHASSIS MOUNTED FUEL LINE THAT CONNECTS TO THE ENGINE WAS ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD. THE LINE COULD CONTACT THE MANIFOLD.

Remedy: DEALERS WILL INSTALL AN ADDITIONAL CLIP TO HOLD THE FUEL LINE IN THE INTENDED DESIGN POSITION.

VEHICLE SPEED CONTROL

VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WI…

Remedy: DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.

POWER TRAIN:AUTOMATIC TRANSMISSION

VEHICLE DESCRIPTION: ELECTRIC VEHICLES. THE TRANSAXLE MAY HAVE BEEN MANUFACTURED WITH THE PARK DETENT SPRING MISALIGNED. IF THE SPRING IS MISALIGNED, THE PARK MECHANISM MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION.

Remedy: DEALERS WILL INSPECT THE TRANSAXLE AND ANY WITH MISALIGNED PARK DETENT SPRINGS WILL BE REPLACED.

STRUCTURE

I BOUGHT THIS TRUCK NEW, I HAVE HAD TRANSMISSION PROBLEMS BUT NOW MY FRAME IS IN BAD, BAD, BAD RUSTING CONDITION AND MY MECHANIC SAID IT WILL NOT PASS INSPECTION. THIS TRUCK ONLY HAS 82,000 MILES ON IT!!! TOYOTA STOOD BEHIND THEIR FRAMES WHY ISN'T FORD?

SUSPENSION,UNKNOWN OR OTHER

THE REAR OF THE FRAME RUSTED CAUSING THE BUMPER TO HANG OFF. IT WILL FALL OFF IF NOT ADDRESSED

STRUCTURE

REAR FRAME EXCESSIVE RUSTING. SPARE TIRE CARRIER FELL OFF WHILE DRIVING. ONE SIDE OF BUMPER FELL OFF. NOTICED WHEN I STEPPED ON IT

UNKNOWN OR OTHER

FRAME IS ROTTED OUT

SUSPENSION,POWER TRAIN,ELECTRICAL SYSTEM

4WD STOPPED WORKING SOME TIME AGO, SERVO/ACTUATOR SEEMED TO BE FREE, RECENTLY STARTED MAKING GRINDING NOISES IN THE FRONT RIGHT, SOUNDS LIKE HUB IS SOMEWHERE BETWEEN LOCKED AND UNLOCKED. SORT OF POPS OUT WHEN COMING TO A STOP HVAC DOES NOT WORK, FAN SPEED ONLY INTERIOR COURTESY STOPPED WORKING

SUSPENSION,STRUCTURE

THE FRAME HAS RUSTED SO SEVERELY THAT THE REAR SUSPENSION IS DETACHING FROM FRAME AND FRAME IS ALMOST RUSTED COMPLETELY THROUGH AND WILL SEPARATE SOON. THE SPARE TIRE AND CARRIER HAVE FALLEN OFF WHERE IS WAS ATTACHED TO THE FRAME DUE TO THE EXCESSIVE RUST AND THE BED MOUNTS HAVE RUSTED AWAY AND NO LONGER ATTACH TO THE FRAME LEAVING THE BED WITH NO SOLID MOUN…

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

MY FUSE #27 FOR BACKUP LIGHTS AND THE O/D KEEPS BLOWING OUT AND NOW THE O/D LIGHT FLASHES SOMETIMES I PULLED THE COVER OFF OF THE STEERING COLUMN BUT THE O/D CORD WASN'T PINCHED OR DAMAGED ALSO NO APPEARANCE OF ANY WIRE TOUCHING ANYTHING

SUSPENSION,STRUCTURE

VEHICLE BACK BUMPER FELL OFF DUE TO EXCESSIVE RUST (WHILE IN MOTION). BALL JOINTS, TIE RODS, UPPER AND LOWER CONTROL ARM BRACKETS RUSTED OUT AS WELL AS HOLES IN THE FRAME (ALL IDENTIFIED WHILE STATIONARY).