2000 Jeep wrangler 4x4 4c se

SERVICE BRAKES, HYDRAULIC

CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT …

Remedy: AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

EXTERIOR LIGHTING

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

CERTAIN AFTERMARKET AIRTEX ELECTRIC FUEL PUMPS INSTALLED FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN 1997-2004 JEEP WRANGLER; 1997-2001 JEEP CHEROKEE; 1997-2004 JEEP GRAND CHEROKEE; AND 2000-2003 DODGE DAKOTA VEHICLES. THE PLASTIC ELECTRICAL GROMMET CONNECTORS AT THE TOP OF THE FUEL PUMP MODULE ARE NOT COMPATIBLE WITH AUTOMOTIVE FUELS AND MAY DEGRADE CAUSING A POTENTIAL LEAK PATH FOR FUEL.

Remedy: AIRTEX WILL NOTIFY ITS CUSTOMERS AND WILL REPLACE THE AFFECTED FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 25, 2006. OWNERS MAY CONTACT AIRTEX CUSTOMER SERVICE DEPARTMENT AT 1-800-880-3056.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.

Remedy: DEALERS WILL INSTALL A MANIFOLD SHIELD TO MODIFY THE AIR FLOW CHARACTERISTICS AND TO PREVENT THE ACCUMULATION OF DEBRIS IN THE AREA OF THE #3 CYLINDER. OWNER NOTIFICATION BEGAN MAY 13, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE

EQUIPMENT

BESTOP AFTERMARKET REAR SHELL ROOF RACKS,MANUFACTURED BETWEEN APRIL 27 AND MAY 20, 2004, DESIGNED FOR USE WITH THE BESTOP HARDTOP MADE FOR THE 1986-1995 AND 1997-2003 JEEP WRANGLER. THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK BECAUSE THE LATCH BRACKET MISPOSITIONS THE ROTARY LATCH TO THE COCKPIT COVER. AS A RESULT, THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK AND COULD SE…

Remedy: BESTOP WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS FREE OF CHARGE. OWNER NOTIFICATION BEGAN JUNE 16, 2004. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BESTOP CUSTOMER SERVICE DEPARTMENT AT (800) 845-3567.

PARKING BRAKE

The contact owns a 1994 N/A Jeep Wrangler. The contact stated that the vehicle failed the State Inspection because the VIN was included in NHTSA Campaign Number: 02V041000 (PARKING BRAKE). However, the part to do the recall repair was no longer available. The contact had not experienced a failure. The vehicle was not repaired. The manufacturer was notified o…

FUEL SYSTEM, GASOLINE

The contact owns a 1993 N/A Jeep Wrangler. The contact stated that there was a strong fuel odor coming from the vehicle after the vehicle was refueled. Additionally, the contact stated that the vehicle was experiencing rough idling and reduced power while driving. The vehicle was taken to the dealer, where the contact was informed that the VIN was included i…

SUSPENSION

WE HAVE FOUND THAT AFTER REMOVING THE BOLTS FROM THE CROSS MEMBER UNDER THE JEEP THAT THE HOLES ARE RUSTED OUT. IN FACT THE FRAME ON BOTH SIDES OF OUR JEEP ARE RUSTED THROUGH FROM NOT HAVING ANY DRAIN HOLES FOR THE WATER TO DRAIN OUT.

SUSPENSION,STRUCTURE

FRAME ROTTED FROM THE INSIDE OUT AROUND THE LOWER CONTROL ARMS. THE CHASSIS IS OTHERWISE RUST FREE, BUT IT SPONTANEOUSLY ROTTED FROM THE INSIDE OUT. THE LOWER CONTROL ARM DISCONNECTED WHILE DRIVING DOWN THE HIGHWAY, LEAVING THE REAR AXLE FREE FLOATING, UNSTABLE, AND VERY LIKELY TO CAUSE A CRASH. THE FRAME HAS HOLES IN IT THAT LET WATER IN. THERE IS NO DRA…

STRUCTURE

THE FRONT FRAME CAP, OR MOUNTING BRACKET HAS STARTED IS ROTTING AND DETERIORATING. THIS IS A MAJOR CONCERN WHICH HAS COURSES MANY OTHER SEVERE ISSUES. THIS IS A MAJOR SUSPENSION COMPONENT THAT IS ROTTING AWAY.

ELECTRICAL SYSTEM

WHILE DRIVING DOWN THE ROAD, SPEED DOESN'T MATTER BC IT HAS HAPPENED AT MULTIPLE SPEEDS, THE SPEEDOMETER AND TACHOMETER WILL DROP TO NOTHING, WHILE THE OTHER GAUGES LIKE GAS, OIL PRESSURE, TEMPERATURE AND SUCH DO NOT HAVE ANY ISSUES AND REMAIN WHERE THEY SHOULD BE! A FEW SECONDS AFTER THE SPEEDOMETER AND TACHOMETER DROP, THE ENGINE LIGHT COMES ON AND THE ODO…

STEERING,UNKNOWN OR OTHER

THE FRONT PORTION OF THE FRAME HAS RUSTED FROM THE INSIDE OUT, NEARLY SEVERING THE STEERING GEAR BOX AND FRAME, FROM THE REST OF THE FRAME. IN ADDITION THE FRAME IN THE SAME LOCATION ON THE PASSENGER SIDE WAS ALSO SOFT TO THE POINT THAT I COULD COMPRESS THE FRAME WITH MY BARE HAND. I DISCOVERED THE PROBLEM AFTER INVESTIGATING WHY THE JEEP WAS SUDDENLY DIFFIC…

SUSPENSION,STRUCTURE,UNKNOWN OR OTHER

2000 JEEP WRANGLER TJ WITH VISIBLE FRAME RUST IN FRONT OF REAR WHEELS. LACK OF DRAINAGE HOLES ALLOWS WATER TO ENTER THROUGH FACTORY DRILLED FRAME HOLES LOCATED IN FRONT AND REAR WHEEL WELLS AND ACCUMULATE IN THE LOWER PARTS OF THE FRAME. BY THE TIME RUST IS VISIBLE ON THE OUTSIDE OF THE FRAME, THE INSIDE HAS ALREADY BEEN COMPROMISED TO A GREATER DEGREE AS TH…