Model year guide

2002 GMC Envoy XL

Recalls, most-reported problems, crash-test ratings, fuel economy and what a 2002 GMC Envoy XL is worth — from official NHTSA and EPA data. 15 on record.

2002 GMC Envoy XL at a glance

Safety recalls3
Owner complaints575
Combined16 mpg
Typical price$2,139

Free: specs, open recalls for that exact car, build sheet and fair price.

2002 GMC Envoy XL recalls 3

Latches/locks/linkages:doors:latch NHTSA Campaign #05V494000 · 27/10/2005

CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, …

Fix: DEALERS WILL INSTALL A SEAL ALONG THE LOWER PART OF THE ROCKER PANEL TO PREVENT INTRUSION OF CORROSIVE MATERIAL, AND INSPECT THE REAR SIDE CLOSURE LATCHES. FUNCTIONAL LATCHES WILL BE CLEANED AND LUBRICATED. NON-FUNCTIONING LATCHES WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 24, 2006. OWNERS …

Exterior Lighting:brake Lights NHTSA Campaign #04V527000 · 01/11/2004

ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.

Fix: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.

Visibility:windshield Wiper/washer NHTSA Campaign #04V046000 · 04/02/2004

CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.

Fix: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1…

Source: U.S. NHTSA. A recall applies to a model year, but only a VIN check shows whether a specific car has had the repair done.

2002 GMC Envoy XL common problems

The most-reported problem areas from 575 owner complaints filed with NHTSA — and what to check before you buy.

Fuel/propulsion System
Check for fuel or battery warnings, hard starts and stalling. On a hybrid/EV, confirm charging and range behave normally.
Structure
Inspect for rust, fresh undercoating, mismatched paint, uneven panel gaps and any sign of prior collision or frame repair.
Electrical System
Test every electrical feature: windows, locks, infotainment, charging and all lights. Watch for flickering, dead accessories or warning lights.
Engine
Listen for knocks or ticking, check for leaks and blue/white exhaust smoke, and make sure it doesn't overheat. No check-engine light should be on.
Seat Belts
Check that every belt latches, retracts and locks under a sharp tug, and that none are frayed.
Power Train
Drive through every gear: watch for slipping, hard or delayed shifts, and shudder. Check for transmission/driveline leaks and noises.

2002 GMC Envoy XL MPG & running costs

Combined16 mpg
City14 mpg
Highway19 mpg
Est. annual fuel cost$3,975

Source: U.S. EPA / DOE fueleconomy.gov, averaged across trims.

What's a 2002 GMC Envoy XL worth?

Low
$1,200
Typical price
$2,139
High
$3,500

From 14 comparable 2002 GMC Envoy XL listings.

Estimated 5-year cost to own

A rough guide to what running a 2002 GMC Envoy XL costs over five years and 75,000 miles.

Fuel (5 yrs)$19,875
Fuel only$19,875
Per mile$0.27

How this is estimated: fuel is the U.S. EPA annual cost at 15,000 miles a year. There aren't enough comparable listings to estimate depreciation for this model, so it is left out. Not included: insurance, maintenance, repairs, taxes, registration and finance costs. Treat it as a comparison guide, not a quote.

2002 GMC Envoy XL trims & engines on record

Trims
SLT · SLE
Engines
4.2L 6-cyl

2002 GMC Envoy XL vehicles on record

2002 GMC Envoy XL SLT1GKET16S026115763 2002 GMC Envoy XL 2002 GMC Envoy XL SLE1GKET16S826123402 2002 GMC Envoy XL SLT1GKET16S426134297 2002 GMC Envoy XL 2002 GMC Envoy XL SLE1GKET16S226103002 2002 GMC Envoy XL SLT1GKET16S326133853 2002 GMC Envoy XL 2002 GMC Envoy XL SLT1GKET16S426124739 2002 GMC Envoy XL 2002 GMC Envoy XL SLE1GKET16S526120019 2002 GMC Envoy XL 2002 GMC Envoy XL SLT1GKET16S126106473 2002 GMC Envoy XL SLT1GKET16S426105110 2002 GMC Envoy XL 2002 GMC Envoy XL SLE1GKES16S526137969 2002 GMC Envoy XL 2002 GMC Envoy XL SLT1GKET16S026135334 2002 GMC Envoy XL 2002 GMC Envoy XL SLE1GKES16S526116653 2002 GMC Envoy XL 2002 GMC Envoy XL SLE1GKES16S626132215 2002 GMC Envoy XL 2002 GMC Envoy XL SLT1GKET16SX26112546 2002 GMC Envoy XL SLE1GKET16S326117782

Other GMC Envoy XL model years

2006 2005 2004 2003

2002 GMC Envoy XL — frequently asked questions

Does the 2002 GMC Envoy XL have any safety recalls?

Yes — NHTSA lists 3 safety recalls for the 2002 GMC Envoy XL. Recall repairs are free at any franchised dealer. Whether a specific car still has one open depends on its VIN.

What are the most common problems with the 2002 GMC Envoy XL?

Based on 575 owner complaints filed with NHTSA, the most-reported problem areas are fuel/propulsion system, structure, electrical system.

What gas mileage does the 2002 GMC Envoy XL get?

The U.S. EPA rates the 2002 GMC Envoy XL at about 16 mpg combined (14 city / 19 highway).

How much is a 2002 GMC Envoy XL worth?

Comparable 2002 GMC Envoy XL listings run roughly $1,200–$3,500, typically around $2,139 (from 14 vehicles).

Sources: NHTSA (recalls, complaints, crash tests), U.S. EPA (fuel economy). Vehicle data only — CarLogs never shows owner information.